...

COAXICON Series Mobile Phone Switching Coax Connectors Product Facts

by user

on
Category: Documents
8

views

Report

Comments

Transcript

COAXICON Series Mobile Phone Switching Coax Connectors Product Facts
RF Coax Connectors
COAXICON Series Mobile Phone Switching Coax Connectors
Product Facts
■
Able to switch RF signal
from internal to external
antenna
■
SMD component for
standard pick & place
■
Up to 2.4 GHz
■
Up to 30,000 life cycles
■
High radial and axial
tolerance capture
■
Low insertion loss
■
Right-angle cable plug with
floating for alignment
tolerance capture
■
Application in handsets
Product Specification
108-71000
Technical Features
Impedance — 50 Ohms
Operating Temperature —
–40°C to +85°C
Radial Tolerance Capture —
±1.0 [.039] (except for 3.5 [.138] height)
Axial Tolerance Capture — 0.6 [.024]
Plating — Outer shell and center
contact are gold plated
Short Stamped Contact —
Selective gold plating
Long Stamp Contact (switch) —
Full gold plating with ink barrier
Insertion Loss — 0.30 dB max.
at 2 GHz
Isolation — 26 dB min. at 2 GHz
VSWR — 1.15:1 at 1 GHz, below
1.20:1 at 2 GHz
Mated Insertion Loss (after life
cycle testing) — Below 0.30 dB at
1 GHz, below 0.45 dB at 2 GHz
Unmated Insertion Loss (after life
cycle testing) — Below 0.20 dB at
1 GHz, below 0.35 dB at 2 GHz
Packaging on reels for SMD.
For more details, refer to the product
specification.
The Tyco Electronics SMD
mobile phone connector
system offers a low-cost
and effective solution to
passive switching between
an internal and external
phone antenna. When
implemented in a cradle kit,
the connector helps to
make possible hands-free
operation of the mobile
phone within a vehicle,
enhancing safety and permitting compliance with a
growing body of legislation.
Connection to the external
antenna also enhances
signal gain and clarity.
The connector design
accommodates gross misalignment between the
Figure 1 — System Configuration
phone and cradle, which is
extremely important when
blindmating is necessary.
The Tyco Electronics switching coax connector system
meets all performance
objectives, including up to
30,000 connect/disconnect
and switching cycles over
the connector’s life.
Figure 2 — System Configuration
229
Catalog 1307191
Revised 3-07
www.tycoelectronics.com
Dimensions are in millimeters
and inches unless otherwise
specified. Values in brackets
are standard equivalents.
Dimensions are shown for
reference purposes only.
Specifications subject
to change.
USA: 1-800-522-6752
Canada: 1-905-470-4425
Mexico: 01-800-733-8926
C. America: 52-55-1106-0803
South America: 55-11-2103-6000
Hong Kong: 852-2735-1628
Japan: 81-44-844-8013
UK: 44-8706-080-208
RF Coax Connectors
COAXICON Series Mobile Phone Switching Coax Connectors (Continued)
Right-Angle Cable Plugs
L1
L2
A
D
F
Note: Hex Crimp Dim. 3.25 [.128]
RG/U
Cable
A
5x5 Square
5x5 Square
6.0
.236
6.0
.236
6.0
.236
6.0
.236
RG 174
D
3.4
.134
3.4
.134
3.4
.134
3.4
.134
3.4
.134
3.4
.134
Dimensions
F
6.9
.272
9.6
.378
6.9
.272
9.6
.378
6.9
.272
9.6
.378
SMD Switching Jacks
L1
15.6
.614
15.6
.614
15.8
.622
15.8
.622
20.3
.799
20.3
.799
L2
10.9
.429
10.9
.429
10.9
.429
10.9
.429
11.0
.433
11.0
.433
Single Packed
Part No.
Bulk Packed
Part No.
619028-2
5-619028-2
619028-4
5-619028-4
619041-2
5-619041-2
619041-4
5-619041-4
619078-1
5-619078-3
619078-2
5-619078-4
D
H
l
L
H
6.0
.236
4.5
.177
3.5
.137
Dimensions
L
8.0
.315
8.0
.315
8.0
.315
l
Diameter
D
Part No.
3.2
.126
3.2
.126
3.2
.126
5.4
.213
5.4
.213
5.4
.213
619061-1
619062-1
619072-1
Other models upon request.
For all dimensions, stencil and PCB recommended layout, see customer
drawing.
*Dim. l is the width of the connector on the PCB.
Note: Part Numbers are RoHS compliant except: Indicates non-RoHS compliant.
230
Catalog 1307191
Revised 3-07
www.tycoelectronics.com
Dimensions are in millimeters
and inches unless otherwise
specified. Values in brackets
are standard equivalents.
Dimensions are shown for
reference purposes only.
Specifications subject
to change.
USA: 1-800-522-6752
Canada: 1-905-470-4425
Mexico: 01-800-733-8926
C. America: 52-55-1106-0803
South America: 55-11-2103-6000
Hong Kong: 852-2735-1628
Japan: 81-44-844-8013
UK: 44-8706-080-208
RF Coax Connectors
COAXICON Series Mobile Phone Switching Coax Connectors (Continued)
Switching SMD Jack
Low Profile
Part Number 619061-1,
Part Number 619062-1, and
Part Number 619072-1
0.42
[.017
± 0.08
± .003]
2.70 ± 0.25
[.106 ± .010]
Ø 5.00
[.197]
2.10 ± 0.10
[.083 ± .004]
3.10 ± 0.10
[.122 ± .004]
Ø 5.10
[.201]
2.40 ± 0.10
[.094 ± .004]
0.80 ± 0.05
[.031 ± .002]
4.30 ± 0.10
[.169 ± .004]
Detail X
3.20 ± 0.10
[.126 ± .004]
3.80 ± 0.10
[.150 ± .004]
Detail Y
3.70 ± 0.10
[.146 ± .004]
8.00 ± 0.20
[.315 ± .008]
0.00
Ø 3.40 +– 0.05
+ .000
[.134 – .002 ]
Ø 5.40
[.213]
Ø 0.60
[.024]
A
Center Contact
Dielectric
Outer Shell
Second
Signal
Contact
1.70
[.067]
Spring
Y
Section A-A
Area Without
Trace
2.40
[.094
A
A
0.10 ± 0.020
[.004 ± .0008]
2.70 ± 0.10
[.106 ± .004]
0.20 ± 0.07
[.008 ± .003]
3.10 ± 0.05
[.122 ± .002]
Ground
Ground With
Solder Stop Mask
± 0.10
± .004]
Signal With
Solder Stop Mask
0.90 ± 0.05
[.035 ± .002]
Signal
0.10
R 1.50 +– 0.00
+ .004
[.059 – .000 ]
R 2.70 ± 0.05
[.106 ± .002]
3.65 ± 0.05
[.144 ± .002]
3.05 ± 0.05
[.120 ± .002]
0.080
4.58 +– 0.070
0.080
3.97 +– 0.070
+ .0031
+ .0031
[.180 – .0028 ]
[.156 – .0028 ]
Recommended PCB Layout
Plating
Gold
Gold
Gold
Dim. A
6.00 ± 0.10
.236 ± .004
4.50 ± 0.10
.177 ± .004
3.50 ± 0.10
.138 ± .004
Part No.
619061-1
619062-1
619072-1
Note: Part Numbers are RoHS compliant except: Indicates non-RoHS compliant.
231
Catalog 1307191
Revised 3-07
www.tycoelectronics.com
Dimensions are in millimeters
and inches unless otherwise
specified. Values in brackets
are standard equivalents.
Dimensions are shown for
reference purposes only.
Specifications subject
to change.
USA: 1-800-522-6752
Canada: 1-905-470-4425
Mexico: 01-800-733-8926
C. America: 52-55-1106-0803
South America: 55-11-2103-6000
Hong Kong: 852-2735-1628
Japan: 81-44-844-8013
UK: 44-8706-080-208
RF Coax Connectors
COAXICON Series Mobile Phone Switching Coax Connectors (Continued)
Switching SMD Jack
ESD Protected
Part Number 619133-3
Plating — Gold
2.35
Max.
[.093]
R 1.40
[.055]
2.45 4.60 ± 0.30
[.096] [.181 ± .012]
3.20
[.126]
0.80
[.031]
Ø 5.40 ± 0.10
[.213 ± .004]
A
Center
Contact
Dielectric
Spring
Outer Shell
6.30 ± 0.10
[.248 ± .004]
1.64
[.065]
Second
Signal
Spring
Contact
3.70 ± 0.25
[.146 ± .010]
7.00
[.276]
8.00
[.315]
0.50
[.020]
A
0.25 ± 0.10
[.010 ± .004]
Section A-A
Area Without
Track
2.70 ± 0.10
[.106 ± .004]
0.05
3.10 +– 0.00
+ .002
[.122 – .000 ]
Ground
Ground With
Solder Stop Mask
2.40 ± 0.10
[.094 ± .004]
Signal With
Solder Stop Mask
0.90 ± 0.05
[.035 ± .002]
Signal
0.05
R 2.70 +– 0.00
+ .002
[.106 – .000 ]
3.65 ± 0.05
[.144 ± .002]
0.10
R 1.50 +– 0.00
+ .004
[.059 – .000 ]
3.05 ± 0.05
[.120 ± .002]
0.080
4.58 +– 0.070
+ .0031
[.180 – .0028 ]
0.080
3.97 +– 0.070
+ .0031
[.156 – .0028 ]
Recommended PCB Layout
Note: Part Numbers are RoHS compliant except: Indicates non-RoHS compliant.
232
Catalog 1307191
Revised 3-07
www.tycoelectronics.com
Dimensions are in millimeters
and inches unless otherwise
specified. Values in brackets
are standard equivalents.
Dimensions are shown for
reference purposes only.
Specifications subject
to change.
USA: 1-800-522-6752
Canada: 1-905-470-4425
Mexico: 01-800-733-8926
C. America: 52-55-1106-0803
South America: 55-11-2103-6000
Hong Kong: 852-2735-1628
Japan: 81-44-844-8013
UK: 44-8706-080-208
RF Coax Connectors
COAXICON Series Mobile Phone Switching Coax Connectors (Continued)
Switching SMD Jack
ESD Protected
4.1mm Height
Part Number 619201-1*
5.00
[.197]
0.80
[.031]
1.50
[.059]
Ø 5.80 ± 0.20
[.228 ± .008]
1.60
[.063]
Ø 4.40 ± 0.20
[.173 ± .008]
Plating — Gold
0.70
[.028]
Ø 6.20
[.244]
0.70
[.028]
0.00
Ø 3.40 +– 0.05
+ .000
[.134 – .002 ]
Ø 0.56
[.022]
Outer Shell
Center Contact
3.45
[.136]
1.07
[.042]
3.88
[.153]
Dielectric
1.80 ± 0.20
[.071 ± .008]
Spring Contact
Mated Position
Ø 4.35
[.171]
2.50
[.098]
0.15
1.00 +– 0.10
+ .006
[.039 – .004 ]
4 Plcs.
R 0.28
[.011]
1.00
[.039]
45°
Ø 5.00
[.197]
Recommended PCB Layout
4.10
[.161]
1.80
[.071]
Unmated Position
*Mirrored Version of Part Number 619201-1 Also Available Under Part Number 619231-1
Switching SMD Jack Mid
Part Number 619075-1
Plating — Gold
B
B
2.90
60°
[.114]
0.70
[.028]
5.50 ± 0.10
[.217 ± .004]
0.40
Sq.
[.016]
1.90
0.70 [.075] 1.85
[.028]
[.073]
1.60
[.063]
0.80
[.031]
0.10 ± 0.02
[.039 ± .001]
R 0.30
[.012]
Ø 5.00 ± 0.10
[.197 ± .004]
1.25
R 1.75 [.049]
[.069]
R 2.50
[.098]
0.50 ± 0.05
[.020 ± .002]
R 0.20
[.008]
Ø 2.50
[.098]
0.40
[.016]
3.50
[.138]
Dielectric,
Plated
38°
Dielectric,
Unplated
D
1.00
[.039]
2.40 ± 0.10
[.094 ± .004]
Ø 4.20
[.165]
D
Spring Contact 0.20
[.008]
Section B-B
Section D-D
2.80
[.110]
0.40
[.016]
Note: Part Numbers are RoHS compliant except: Indicates non-RoHS compliant.
233
Catalog 1307191
Revised 3-07
www.tycoelectronics.com
Dimensions are in millimeters
and inches unless otherwise
specified. Values in brackets
are standard equivalents.
Dimensions are shown for
reference purposes only.
Specifications subject
to change.
USA: 1-800-522-6752
Canada: 1-905-470-4425
Mexico: 01-800-733-8926
C. America: 52-55-1106-0803
South America: 55-11-2103-6000
Hong Kong: 852-2735-1628
Japan: 81-44-844-8013
UK: 44-8706-080-208
RF Coax Connectors
COAXICON Series Mobile Phone Switching Coax Connectors (Continued)
Micro Switching Coax
Connector
Part Number 619196-1
Plating — Gold
1.30
[.051]
Contact Spring
Ø 1.70
[.067]
10.40
[.409]
Shell Angle
Outer
Shell
Plating — Gold
Lid
Ferrule
Nano Switching Coax
Part Number 619213-1
Ground
Ø 3.00
[.118]
8.10
[.319]
1.00
[.039]
A
3.00 ± 0.20
[.118 ± .008] 1.80
[.071]
2.00
[.079]
1.70
[.067]
Input Signal
A
Dielectric,
Unplated
Section A-A
0.70
[.028]
3.40
[.134]
Dielectric,
Plated
2.50
[.098]
3.20
[.126]
Output
Signal
1.54
[.061]
Ø 0.80
[.031]
Right-Angle Cable Plug For
Micro Switching Coax
Connector Cable RG 316/
RG 174
Part Number 619211-2
0.70
[.028]
3.00
[.118]
Ø 3.00
[.118]
0.80
[.031]
Copper
0.90
Clearance
[.035]
1.40
[.055]
Recommended PCB Layout
Dielectric
Snap Spring
Center
Contact
Ø 0.70 Ø 3.50
[.028] [.138]
2.20
[.087]
5.10 Sq.
[.201]
4.80
[.189]
7.00
[.276]
0.45
[.018]
1.25 ± 0.05
[.049 ± .002]
Plating — Gold
0.60
[.024]
3.00 ± 0.05
[.118 ± .002]
1.05 ± 0.05
[.041 ± .002]
Ø 1.92 ± 0.15
[.076 ± .006]
2.65 ± 0.05
[.104 ± .002]
2.90
[.114]
1.70 ± 0.15
[.067 ± .006]
2.70 ± 0.15
[.106 ± .006]
1.55 ± 0.05
[.061 ± .002]
1.25 ± 0.05
[.049 ± .002]
0.30 ± 0.05
[.012 ± .002]
0.55 ± 0.05
[.022 ± .002]
Recommended PCB Layout
2.70 ± 0.15
[.106 ± .006]
1.45
[.057]
Ø 0.55
[.022]
Note: Part Numbers are RoHS compliant except: Indicates non-RoHS compliant.
234
Catalog 1307191
Revised 3-07
www.tycoelectronics.com
Dimensions are in millimeters
and inches unless otherwise
specified. Values in brackets
are standard equivalents.
Dimensions are shown for
reference purposes only.
Specifications subject
to change.
USA: 1-800-522-6752
Canada: 1-905-470-4425
Mexico: 01-800-733-8926
C. America: 52-55-1106-0803
South America: 55-11-2103-6000
Hong Kong: 852-2735-1628
Japan: 81-44-844-8013
UK: 44-8706-080-208
RF Coax Connectors
COAXICON Series Mobile Phone Switching Coax Connectors (Continued)
Protected Front Contact
Cable Plug
Part Number 5-619028-1,
Part Number 5-619078-1,
and Part Number 5-619137-1
3.40
[.134]
A
Safety
Spring Ring
Ø 9.60
[.378]
5.10
[.201]
Dielectric
Ø 9.60
[.378]
Plating
7.35
[.289]
Center
Contact
Lid
Gold
Outer
Shell
Gold
Spring Support
Gold
Washer
Shell Angle
Protected Front Contact
Cable Plug With
Cylindrical Interface
Part Number 5-619076-2
Part No.
5-619028-1
5-619078-1
*5-619137-1*
Bulk packaging.
*Outer conductor without slot.
Ferrule
15.60
[.614]
10.92
[.430]
6.62
[.261]
Dielectric
5.00 ± 0.25
[.197 ± .010]
0.110
Ø 2.50 +– 0.010
+ .0043
[.098 – .0004 ]
Safety
Ring
Plating — Gold
Bulk packaging.
Dim. A
10.92
.430
14.90
.587
10.92
.430
5.10
7.35 [.201]
[.289]
Ø 9.60
[.378]
5.67
[.223]
Lid
Spring
Shell Angle
Center
Outer Contact
Shell
Ø 3.50 ± 0.025
[.138 ± .0010]
Spring Support
Washer
Ferrule
Cable Plug/
SMA Jack Adapter
Part Number 619052-1
7.00
[.276]
Plating — Gold
35.00
[1.378]
22.00
[.866]
13.00
[.512]
Safety Ring
6.62
[.261]
Dielectric
Dielectric
Center Contact
Ø 10.00
[.394]
1/4" - 36 UNS-2A
Cable Plug/
SMA Jack Adapter
With Conical Flange
Part Number 619068-1
7.00
[.276]
Plating — Gold
Ø 6.50
[.256]
22.00
[.866]
35.00
[1.378]
Dielectric
Outer
Shell
5.47
[.215]
13.00
[.512]
6.62
Ø 8.18
[.261]
[.322]
Ø 3.40
[.134]
Safety Ring
Dielectric
Center Contact
Ø 10.00
[.394]
1/4" - 36 UNS-2A
Ø 6.50
[.256]
Outer
Shell
5.47
[.215]
Ø 3.40
[.134]
Note: Part Numbers are RoHS compliant except: Indicates non-RoHS compliant.
235
Catalog 1307191
Revised 3-07
www.tycoelectronics.com
Dimensions are in millimeters
and inches unless otherwise
specified. Values in brackets
are standard equivalents.
Dimensions are shown for
reference purposes only.
Specifications subject
to change.
USA: 1-800-522-6752
Canada: 1-905-470-4425
Mexico: 01-800-733-8926
C. America: 52-55-1106-0803
South America: 55-11-2103-6000
Hong Kong: 852-2735-1628
Japan: 81-44-844-8013
UK: 44-8706-080-208
RF Coax Connectors
COAXICON Series Mobile Phone Switching Coax Connectors (Continued)
Switching SMD Jack/
SMA Jack Adapter
Part Number 619053-1
7.00
[.276]
22.00
[.866]
35.00
[1.378]
13.00
[.512]
Dielectric
Outer Shell
Plating — Gold
Center Contact
Ø 10.00
[.394]
1/4" - 36 UNS-2A
Adapter SMA Jack —
MSC Test Plug
With Conical Flange
Part Number 619210-1
7.00
[.276]
Ø 0.60
[.024]
Ø 6.50
[.256]
22.00
[.866]
Dielectric
20°
Ø 5.40
[.213]
+ 0.020
Ø 3.40 – 0.080
.0008
[.134 +– .0031
]
0.17
13.00 +– 0.12
+ .007
[.512 – .005 ]
Ø 8.18
[.322]
2.90
[.114]
Dielectric
Center Contact
R 0.35
[.014]
Ø 10.00
[.394]
Plating — Gold
Ø 6.50
[.256]
1/4" - 36 UNS-2A
Adapter SMA Jack —
NSC Test Plug With
Two-Hole Flange
Part Number 619214-1
A
14.00 ± 0.10
[.551 ± .004]
A
8.00
[.314
± 0.10
± .004]
Ø 7.00 ± 0.10
[.276 ± .004]
Ø 3.40 ± 0.10
[.134 ± .004]
Ø 5.00 ± 0.10
[.197 ± .004]
Outer
Shell
Ø 20.00 ± 0.10
[.787 ± .004]
Plating — Gold
0.10
Ø 2.60 +– 0.00
+ .004
[.102 – .000 ]
2 Plcs.
Ø 0.70
[.028]
2.20
[.087]
Outer
Shell
11.40
[.449]
Center
Contact
Pin
Ø 3.00
[.118]
1.00 ± 0.10
[.039 ± .004]
Flange
Ø 7.50 ± 0.20
[.295 ± .008]
Center
Contact
Female
Dielectric
Dielectric
8.70 ± 0.20
[.343 ± .008]
6.00 ± 0.10
[.236 ± .004]
18.70 ± 0.20
[.736 ± .008]
28.20 ± 0.30
[1.110 ± .012]
Note: Part Numbers are RoHS compliant except: Indicates non-RoHS compliant.
236
Catalog 1307191
Revised 3-07
www.tycoelectronics.com
Dimensions are in millimeters
and inches unless otherwise
specified. Values in brackets
are standard equivalents.
Dimensions are shown for
reference purposes only.
Specifications subject
to change.
USA: 1-800-522-6752
Canada: 1-905-470-4425
Mexico: 01-800-733-8926
C. America: 52-55-1106-0803
South America: 55-11-2103-6000
Hong Kong: 852-2735-1628
Japan: 81-44-844-8013
UK: 44-8706-080-208
Fly UP